Abstract:
Supported base metal catalysts were tested for the preferential oxidation of CO (CO PROX). The catalysts we investigated covered a wide range of transition metals (Co, Cr, Cu, Ni, Zn) supported on oxides with very different acidic, basic and redox properties (MgO, La2O3, SiO 2-Al2O3, CeO2, Ce 0.63Zr0.37O2). The influence of the metal loading (Cu), the support properties (acidity, basicity, redox, surface area) and the reaction conditions (reaction temperature, feed composition) on the catalyst activity and selectivity was evaluated. The activity of ceria and ceria-zirconia supported copper catalysts was comparable to the performances of noble metal samples classically used for the PROX reaction. In addition, Cu-CeO2 catalysts showed a practically constant and high selectivity towards CO oxidation in the temperature range of 50-150°C. Due to the strong synergetic effect between copper and ceria, only a small amount of copper (0.3 wt.%) was necessary to get an active catalyst. The best catalytic performances were obtained for the samples containing 1-3 wt.% copper. The presence of small copper particles in close interaction with the ceria support was shown to be responsible for the enhanced activity. Except for the hydrogen oxidation, no parallel reactions (CO or CO2 methanation reactions, coking, RWGS) could be detected over these catalysts. Classically, an increase of the oxygen excess led to an increased CO conversion with a simultaneous loss of selectivity towards CO2. Finally, the presence of CO2 in the feed negatively affected the catalytic activity. This effect was attributed to the adsorption of CO2 on the copper sites, probably as CO. © 2004 Elsevier B.V. All rights reserved.
Registro:
Documento: |
Artículo
|
Título: | Supported base metal catalysts for the preferential oxidation of carbon monoxide in the presence of excess hydrogen (PROX) |
Autor: | Mariño, F.; Descorme, C.; Duprez, D. |
Filiación: | LACCO-UMR 6503, CNRS-Université de Poitiers, 40 Avenue du Recteur Pineau, F-86022 Poitiers Cedex, France Lab. de Procesos Catalíticos, DIQ-FIUBA, Ciudad Universitaria, 1428 Buenos Aires, Argentina Inst. de Recherches Sur la Catalyse, CNRS, 2 Avenue Albert Einstein, F-69626 Villeurbanne Cedex, France
|
Palabras clave: | Base metals; Ceria; Copper; Fuel cells; Hydrogen purification; Oxygen mobility; Preferential oxidation of CO; PROX; Redox; Supported catalysts; Alkalinity; Carbon monoxide; Catalyst activity; Copper; Oxidation; Oxides; Redox reactions; Active catalysts; Metal catalysts; Preferential oxidation; Surface area; Catalysts; Lucia limbaria; Sio |
Año: | 2005
|
Volumen: | 58
|
Número: | 3-4
|
Página de inicio: | 175
|
Página de fin: | 183
|
DOI: |
http://dx.doi.org/10.1016/j.apcatb.2004.12.008 |
Título revista: | Applied Catalysis B: Environmental
|
Título revista abreviado: | Appl. Catal. B Environ.
|
ISSN: | 09263373
|
CODEN: | ACBEE
|
Registro: | https://bibliotecadigital.exactas.uba.ar/collection/paper/document/paper_09263373_v58_n3-4_p175_Marino |
Referencias:
- Oh, S., Sinkevitch, R., (1993) J. Catal., 142, p. 254
- Son, I., Shamsuzzoha, M., Lane, M., (2002) J. Catal., 210, p. 460
- Snytnikov, P., Sobyanin, V., Belyaev, V., Tsyrulnikov, P., Shitova, N., Shlyapin, D., (2003) Appl. Catal. A: Gen., 239, p. 149
- Mariño, F., Descorme, C., Duprez, D., (2004) Appl. Catal. B: Environ., 54, p. 59
- Haruta, M., (1997) Catal. Today, 36, p. 153
- Schubert, M., Venugopal, A., Kahlich, M., Plzak, V., Behm, R., (2004) J. Catal., 222, p. 32
- Costello, C., Yang, J., Law, H., Wang, Y., Lin, J., Marks, L., Kung, M., Kung, H., (2003) Appl. Catal. A: Gen., 243, p. 15
- Liu, W., Sarofin, A., Flytzani-Stephanopoulos, M., (1994) Appl. Catal. B: Environ., 4, p. 167
- Huang, T., Yu, T., (1991) Appl. Catal., 72, p. 275
- Zhang, S., Huang, W., Qiu, X., Li, B., Zheng, X., Wu, S., (2002) Catal. Lett., 80 (1-2), p. 41
- Avgouropoulos, G., Ioannides, T., (2003) Appl. Catal. A: Gen., 244, p. 155
- Wang, J., Shih, W., Huang, T., (2000) Appl. Catal. A: Gen., 203, p. 191
- Kim, D., Cha, J., (2003) Catal. Lett., 86 (1-3), p. 107
- Wang, J., Tsai, D., Huang, T., (2002) J. Catal., 208, p. 370
- Kandoi, S., Gokhale, A., Grabow, L., Dumesic, J., Mavrikakis, M., (2004) Catal. Lett., 93 (1-2), p. 93
- Shan, W., Shen, W., Li, C., (2003) Chem. Mater., 15, p. 4761
- Madier, Y., Descorme, C., Le Govic, A.M., Duprez, D., (1999) J. Phys. Chem. B, 103, p. 10999
- Liu, W., Flytzani-Stephanopoulos, M., (1995) J. Catal., 153, p. 304
- Liu, W., Flytzani-Stephanopoulos, M., (1995) J. Catal., 153, p. 317
- Liu, Y., Fu, Q., Stephanopoulos, M.F., (2004) Catal. Today, 93-95, p. 246
- Xiaoyuan, J., Guanglie, L., Renxian, Z., Jianxin, M., Yu, C., Xiaoming, Z., (2001) Appl. Surf. Sci., 173, p. 208
- Luo, M., Zhong, Y., Yuan, X., Zheng, X., (1997) Appl. Catal. A: Gen., 162, p. 121
- Ratnasamy, P., Srinivas, D., Satyanarayana, C., Manikandan, P., Senthil Kumaran, R., Sachin, M., Shetti, V., (2004) J. Catal., 221, p. 455
- Martinez-Arias, A., Fernández-García, M., Soria, J., Conesa, J., (1999) J. Catal., 182, p. 367
- Martinez-Arias, A., Fernández-García, M., Gálvez, O., Coronado, J., Anderson, J., Conesa, J., Soria, J., Munuera, G., (2000) J. Catal., 195, p. 207
- Wang, J., Lin, S., Huang, T., (2002) Appl. Catal. A: Gen., 232, p. 107
- Jernigan, G., Somorjai, G., (1994) J. Catal., 147, p. 567
- Kacimi, S., Barbier Jr., J., Taha, R., Duprez, D., (1993) Catal. Lett., 22, p. 343
- Kundakovic, Lj., Flytzani-Stephanopoulos, M., (1998) Appl. Catal. A: Gen., 171, p. 13
- Martin, D., Duprez, D., (1996) J. Phys. Chem., 100, p. 9429
- Martin, D., (1994), Ph.D. Thesis, Poitiers University; Osinga, Th., Linsen, B., Van Beek, W., (1967) J. Catal., 7, p. 277
- Dvorak, B., Pasek, J., (1970) J. Catal., 18, p. 108
- Evans, J., Wainwright, M., Bridgwater, A., Young, D., (1983) Appl. Catal., 7, p. 75
- Li, Y., Fu, Q., Flytzani-Stephanopoulos, M., (2000) Appl. Catal. B: Environ., 27, p. 179
- Avgouropoulos, G., Ioannides, T., Matralis, H., Batista, J., Hocevar, S., (2001) Catal. Lett., 73, p. 33
- Avgouropoulos, G., Ioannides, T., Papadopoulou, Ch., Batista, J., Hocevar, S., Matralis, H., (2002) Catal. Today, 75, p. 157
- Sedmak, G., Hocevar, S., Levec, J., (2003) J. Catal., 213, p. 135
- Mars, P., Van Krevelen, D., (1954) Chem. Eng. Sci., 3, p. 41
- Bernal, S., Calvino, J.J., Cifredo, G.A., Rodriguez-Izquierdo, J.M., Perrichon, V., Laachir, A., (1992) J. Catal., 137, p. 1
- Dong, L., Hu, Y., Shen, M., Jin, T., Wang, J., Ding, W., Chen, Y., (2001) Chem. Mater., 13, p. 4227
- Park, P., Ledford, J., (1998) Catal. Lett., 50, p. 41
- Huang, T., Tsai, D., (2003) Catal. Lett., 87 (3-4), p. 173
- Fajardie, F., Tempère, J., Manoli, J., Touret, O., Blanchard, G., Djéga-Mariadassou, G., (1998) J. Catal., 179, p. 469
Citas:
---------- APA ----------
Mariño, F., Descorme, C. & Duprez, D.
(2005)
. Supported base metal catalysts for the preferential oxidation of carbon monoxide in the presence of excess hydrogen (PROX). Applied Catalysis B: Environmental, 58(3-4), 175-183.
http://dx.doi.org/10.1016/j.apcatb.2004.12.008---------- CHICAGO ----------
Mariño, F., Descorme, C., Duprez, D.
"Supported base metal catalysts for the preferential oxidation of carbon monoxide in the presence of excess hydrogen (PROX)"
. Applied Catalysis B: Environmental 58, no. 3-4
(2005) : 175-183.
http://dx.doi.org/10.1016/j.apcatb.2004.12.008---------- MLA ----------
Mariño, F., Descorme, C., Duprez, D.
"Supported base metal catalysts for the preferential oxidation of carbon monoxide in the presence of excess hydrogen (PROX)"
. Applied Catalysis B: Environmental, vol. 58, no. 3-4, 2005, pp. 175-183.
http://dx.doi.org/10.1016/j.apcatb.2004.12.008---------- VANCOUVER ----------
Mariño, F., Descorme, C., Duprez, D. Supported base metal catalysts for the preferential oxidation of carbon monoxide in the presence of excess hydrogen (PROX). Appl. Catal. B Environ. 2005;58(3-4):175-183.
http://dx.doi.org/10.1016/j.apcatb.2004.12.008