Navegar

Colección

Datos Estadísticas

Artículo

Estamos trabajando para incorporar este artículo al repositorio
Consulte el artículo en la página del editor
Consulte la política de Acceso Abierto del editor

Abstract:

Several Cu and Ni samples, supported over Pr-promoted ceria, were characterized and tested as water gas shift (WGS) catalysts in the temperature range 250–450 °C. Three metal loadings were studied, 5, 10 and 20 wt%. Redox (TPR) and textural (XRD and BET) properties were correlated with the observed catalytic behavior. The activity clearly increased with metal loading (Cu or Ni) from 5 to 10 wt%, but no major changes were observed between mid and high metal loading samples, 10 and 20 wt%. This might be due to appreciable metal segregation over support surface as Cu or Ni content increases. For Ni-containing samples, CH4 was found at the reactor outlet stream, showing that CO methanation also takes place. For 10 wt% total metal content, kinetic expressions for monometallic Cu and Ni catalysts, and a bimetallic CuNi were proposed and fitted simultaneously for both WGS and the CO methanation reaction. Then, the kinetic expressions were used to model a reactor scheme where the main goal was the minimization of the required catalyst mass for a given CO conversion. It can be concluded that the most promissory scheme consists of two reactors, the first operating with the CuNi catalyst at high temperature and the second with the Cu catalyst at a lower temperature. © 2017, Akadémiai Kiadó, Budapest, Hungary.

Registro:

Documento: Artículo
Título:Cu and/or Ni catalysts over CePr oxide for the water gas shift reaction: an experimental study, kinetic fitting and reactor simulation
Autor:Poggio-Fraccari, E.; Giunta, P.; Baronetti, G.; Mariño, F.
Filiación:ITHES, UBA-CONICET, Pabellón de Industrias, Ciudad Universitaria, Ciudad Autónoma de Buenos Aires, 1428, Argentina
Palabras clave:Copper nickel catalysts; Hydrogen purification; Reactor design; Water gas shift; Air purification; Catalyst activity; Catalysts; Chemical shift; Fischer-Tropsch synthesis; Hydrogenation; Kinetics; Metals; Methanation; Nickel; Surface segregation; Copper nickels; Hydrogen purification; Kinetic expression; Lower temperatures; Reactor designs; Reactor simulation; Water gas shift (WGS) reaction; Water gas shift catalysts; Water gas shift
Año:2017
Volumen:121
Número:2
Página de inicio:607
Página de fin:628
DOI: http://dx.doi.org/10.1007/s11144-017-1166-2
Título revista:Reaction Kinetics, Mechanisms and Catalysis
Título revista abreviado:React. Kinet. Mech. Catal.
ISSN:18785190
Registro:https://bibliotecadigital.exactas.uba.ar/collection/paper/document/paper_18785190_v121_n2_p607_PoggioFraccari

Referencias:

  • Zalc, M., Löffler, D., Fuel processing for PEM fuel cells: transport and kinetic issues of system design (2002) J Power Sour, 111, pp. 58-64. , COI: 1:CAS:528:DC%2BD38XmslOju7s%3D
  • Amadeo, N., Laborde, M., Hydrogen production from the low-temperature water–gas shift reaction: kinetics, and simulation of the industrial reactor (1995) Int J Hydrog Energy, 20, pp. 949-956. , COI: 1:CAS:528:DyaK2MXpsFKrs7k%3D
  • Ratnasamy, C., Wagner, J., Water gas shift catalysis (2009) Catal Rev, 51, pp. 325-440. , COI: 1:CAS:528:DC%2BD1MXhtFSgsL3O
  • Panagiotopoulou, P., Papavasiliou, B., Avgouropoulos, J., Ionnides, G., Kondarides, T., Water gas shift activities of doped Pt-CeO2 catalysts (2007) Chem Eng J, 134, pp. 16-22. , COI: 1:CAS:528:DC%2BD2sXpvVOrsL8%3D
  • Tiwari, R., Sarkara, B., Tiwari, R., Pendem, C., Sasaki, T., Saran, S., Bal, R., Pt nanoparticles with tuneable size supported on nanocrystallineceria for the low temperature water–gas-shift (WGS) reaction (2014) J Mol Catal, 395, pp. 117-123. , COI: 1:CAS:528:DC%2BC2cXhsVGgt7%2FM
  • Reina, T., Ivanova, S., Centeno, M., Odriozola, J., Boosting the activity of a Au/CeO2/Al2O3catalyst for the WGS reaction (2015) Catal Today, 253, pp. 149-154. , COI: 1:CAS:528:DC%2BC2MXjslOrtro%3D
  • El-Moemen, A., Karpenko, A., Denkwitz, Y., Behm, R., Activity, stability and deactivation behavior of Au/CeO2 catalysts in the water gas shift reaction at increased reaction temperature (300 °C) (2009) J Power Sourc, 190, pp. 64-75
  • Mendes, D., Garcia, H., Silva, V., Mendes, A., Madeira, M., Comparison of nanosized gold-based and copper-based catalysts for the low-temperature water–gas shift reaction (2009) Ind Chem Res., 48, pp. 430-439. , COI: 1:CAS:528:DC%2BD1cXhsVSntbbO
  • Jacobs, G., Chenu, E., Patterson, P., Williams, L., Sparks, D., Thomas, G., Davis, B., Water–gas shift: comparative screening of metal promoters for metal/ceria systems and role of the metal (2004) Appl Catal A Gen, 258, pp. 203-214. , COI: 1:CAS:528:DC%2BD2cXos1Wqtw%3D%3D
  • Bunluesin, T., Gorte, R., Graham, G., Studies of the water-gas-shift reaction on ceria-supported Pt, Pd, and Rh: implications for oxygen-storage properties (1998) Appl Catal B Environ, 15, pp. 107-114. , COI: 1:CAS:528:DyaK2sXns1Cjsro%3D
  • Qi, X., Flytzani-Stephanopoulos, M., Activity and stability of Cu-CeO2 catalysts in high-temperature water–gas shift for fuel-cell applications (2004) Ind Eng Chem Res, 43, pp. 3055-3062. , COI: 1:CAS:528:DC%2BD2cXisVygsLw%3D
  • Gunawardana, P., Lee, H., Kim, D., Performance of copper–ceria catalysts for water gas shift reaction in medium temperature range (2009) Int J Hydrog Energy, 34, pp. 1336-1341. , COI: 1:CAS:528:DC%2BD1MXht1Gmsro%3D
  • Reddy, B., Thrimurthulu, G., Katta, L., Yamada, Y., Park, S., Structural characteristics and catalytic activity of nanocrystalline ceria-praseodymia solid solutions (2009) J Phys Chem C, 113, pp. 15882-15890. , COI: 1:CAS:528:DC%2BD1MXpslOltro%3D
  • Borchert, H., Frolova, Y., Kaichev, V., Prosvirin, I., Sadykov, V., Electronic and chemical properties of nanostructured cerium dioxide doped with praseodymium (2005) J Phys Chem C, 109, pp. 5728-5738. , COI: 1:CAS:528:DC%2BD2MXhvVSiuro%3D
  • Poggio-Fraccari, E., Mariño, F., Laborde, M., Baronetti, G., Copper and nickel catalysts supported on praseodymium-doped ceria (PDC) for the water–gas shift reaction (2013) Appl Catal A Gen, 460, pp. 15-20
  • Li, Y., Qi, F., Flytzani-Stephanopoulos, M., Low-temperature water-gas shift reaction over Cu- and Ni-loaded cerium oxide catalysts (2002) Appl Catal B Environ, 27, pp. 179-191
  • Wheeler, C., Jhalani, A., Klein, E., Tummala, S., Schmidt, L., The water–gas-shift reaction at short contact times (2004) J Catal, 223, pp. 191-199. , COI: 1:CAS:528:DC%2BD2cXislWjsLg%3D
  • Poggio-Fraccari, E., Irigoyen, B., Baronetti, G., Mariño, F., Ce-Pr mixed oxides as active supports for water–gas shift reaction: experimental and density functional theory characterization (2014) Appl Catal A Gen, 485, pp. 123-132. , COI: 1:CAS:528:DC%2BC2cXhtlaqsr%2FJ
  • Giunta, P., Moreno, M., Mariño, F., Amadeo, N., Laborde, M., COPROX fixed bed reactor temperature control schemes (2012) Chem Eng J, 35, pp. 1055-1063. , COI: 1:CAS:528:DC%2BC38Xmtlynt70%3D
  • Jeifetz, L., Giunta, P., Mariño, F., Amadeo, N., Laborde, M., Simulation of CO preferential oxidation (COPrOx) monolithic reactors (2014) Int J Chem React Eng, 12, pp. 1-12. , COI: 1:CAS:528:DC%2BC2cXhslSksrvO
  • Colón, G., Pijolat, M., Valdivieso, F., Vidal, H., Kaspar, J., Finocchio, E., Surface and structural characterization of CexZr1–xO2 CEZIRENCAT mixed oxides as potential three-way catalyst promoters (1998) J Chem Soc Faraday Trans, 94, pp. 3717-3726
  • Jobbágy, M., Mariño, F., Schönbrod, B., Baronetti, G., Laborde, M., Synthesis of copper-promoted CeO2 catalysts (2006) Chem Mater, 18, pp. 1945-1950
  • Rico-Pérez, V., Aneggi, E., Bueno-López, A., Trovarelli, A., Synergic effect of Cu/Ce0.5Pr0.5O2–x and Ce0.5Pr0.5O2–x in soot combustion (2016) Appl Catal B Environ., 197, pp. 95-104
  • Moreira, M., Ribeiro, A., Cunha, A., Rodrigues, A., Zabilsky, M., Djinovic, P., Pintar, A., Copper based materials for water-gas shift equilibrium displacement (2016) Appl Catal B Environ, 189, pp. 199-209. , COI: 1:CAS:528:DC%2BC28Xjs1Ggsbg%3D
  • Caputo, T., Lisi, L., Pirone, R., Russo, G., On the role of redox properties of CuO/CeO2 catalysts in the preferential oxidation of CO in H2-rich gases (2008) Appl Catal A Gen, 328, pp. 42-53
  • Luo, M., Zhong, Y., Yuan, X., Zheng, X., TPR and TPD studies of CuO/CeO2 catalysts for low temperature CO oxidation (1997) Appl Catal A Gen, 162, pp. 121-131. , COI: 1:CAS:528:DyaK2sXmt1alt78%3D
  • Rao, G., Sahu, H., Mishra, B., Surface and catalytic properties of Cu–Ce–O composite oxides prepared by combustion method (2003) Coll Surf A, 220, pp. 261-269. , COI: 1:CAS:528:DC%2BD3sXks1KgtLk%3D
  • Du, X., Zhang, D., Shi, L., Gao, R., Zhang, J., Morphology dependence of catalytic properties of Ni/CeO2 nanostructures for carbon dioxide reforming of methane (2004) J Phys Chem C, 116, pp. 10009-10016
  • Chary, K., Rao, P., Vishwanathan, V., Synthesis and high performance of ceria supported nickel catalysts for hydrodechlorination reaction (2006) Catal Commun, 7, pp. 974-978. , COI: 1:CAS:528:DC%2BD28XhtFWiurvM
  • Liu, W., Flitzany-Stephanopoulos, M., Total oxidation of carbon monoxide and methane over transition metal-fluorite oxide composite catalyst (1995) J Catal, 153, pp. 317-332. , COI: 1:CAS:528:DyaK2MXltlOqtb8%3D
  • Fatsikostas, A., Verykios, X., Reaction network of steam reforming of ethanol over Ni-based catalysts (2004) J Catal, 225, pp. 439-452. , COI: 1:CAS:528:DC%2BD2cXltVCrtbo%3D
  • Huang, T., Yu, T., Jhao, S., Weighting variation of water–gas shift in steam reforming of methane over supported Ni and Ni–Cu catalysts (2006) Ind Eng Chem Res, 45, pp. 150-156. , COI: 1:CAS:528:DC%2BD2MXhtFyrur7N
  • Zyryanova, M., Snytnikov, P., Amosov, Y., Kuzmin, V., Kirillov, V., Sobyanin, V., Design, scale-out, and operation of a preferential CO methanation reactor with a nickel ceria catalyst (2001) Chem Eng J, 176, pp. 106-113
  • Lin, J., Biswas, P., Guliants, V., Misture, S., Hydrogen production by water–gas shift reaction over bimetallic Cu–Ni catalysts supported on La-doped mesoporous ceria (2010) Appl Catal A Gen, 387, pp. 87-94. , COI: 1:CAS:528:DC%2BC3cXht1Srt7bE
  • Shinde, V., Madras, G., Water gas shift reaction over multi-component ceria catalysts (2002) Appl Catal B Environ, 123, pp. 367-378
  • Koryabkina, N., Phatak, A., Ruettinger, W., Farrauto, R., Ribeiro, F., Determination of kinetic parameters for the water–gas shift reaction on copper catalysts under realistic conditions for fuel cell applications (2003) J Catal, 217, pp. 233-239. , COI: 1:CAS:528:DC%2BD3sXktVGqu70%3D
  • Zerva, C., Philippopoulos, C., Ceria catalysts for water gas shift reaction: influence of preparation method on their activity (2006) Appl Catal B Environ, 67, pp. 105-112. , COI: 1:CAS:528:DC%2BD28Xosl2gtbg%3D
  • Si, R., Raitano, J., Yia, N., Zhang, L., Chan, S., Flytzani-Stephanopoulos, M., Structure sensitivity of the low-temperature water–gas shift reaction on Cu–CeO2 catalysts (2012) Catal Today, 180, pp. 68-80. , COI: 1:CAS:528:DC%2BC38XivVaruw%3D%3D
  • Strogatz, S., (1994) Nonlinear dynamics and chaos, , Addison-Wesley Reading, Boston
  • Prigogine, I., (1961) Introduction to thermodynamics of irreversible processes, , Wiley, New York
  • de Groot, S., Mazur, P., (1985) Non-equilibrium thermodynamics, , Dover Publications Inc., New York

Citas:

---------- APA ----------
Poggio-Fraccari, E., Giunta, P., Baronetti, G. & Mariño, F. (2017) . Cu and/or Ni catalysts over CePr oxide for the water gas shift reaction: an experimental study, kinetic fitting and reactor simulation. Reaction Kinetics, Mechanisms and Catalysis, 121(2), 607-628.
http://dx.doi.org/10.1007/s11144-017-1166-2
---------- CHICAGO ----------
Poggio-Fraccari, E., Giunta, P., Baronetti, G., Mariño, F. "Cu and/or Ni catalysts over CePr oxide for the water gas shift reaction: an experimental study, kinetic fitting and reactor simulation" . Reaction Kinetics, Mechanisms and Catalysis 121, no. 2 (2017) : 607-628.
http://dx.doi.org/10.1007/s11144-017-1166-2
---------- MLA ----------
Poggio-Fraccari, E., Giunta, P., Baronetti, G., Mariño, F. "Cu and/or Ni catalysts over CePr oxide for the water gas shift reaction: an experimental study, kinetic fitting and reactor simulation" . Reaction Kinetics, Mechanisms and Catalysis, vol. 121, no. 2, 2017, pp. 607-628.
http://dx.doi.org/10.1007/s11144-017-1166-2
---------- VANCOUVER ----------
Poggio-Fraccari, E., Giunta, P., Baronetti, G., Mariño, F. Cu and/or Ni catalysts over CePr oxide for the water gas shift reaction: an experimental study, kinetic fitting and reactor simulation. React. Kinet. Mech. Catal. 2017;121(2):607-628.
http://dx.doi.org/10.1007/s11144-017-1166-2